Term
| 47 MLB NORMAL ENGINE TEMPETATURE |
|
Definition
|
|
Term
| 47 MLB MAJOR ENGINE TEMPERATURES |
|
Definition
| BELOW 140 AND 193-204 DEGREES F |
|
|
Term
| 47 MLB MAJOR ENGINE TEMPERATURE |
|
Definition
|
|
Term
| 47 MLB DISABLING ENGINE TEMPERATURE |
|
Definition
|
|
Term
| ENGINE OIL PRESSURES CRUISING AND AT IDLE |
|
Definition
| CRUISING 49-70 PSI AT IDLE A MINIUM OF 5 PSI |
|
|
Term
| REDUCTION GEAR OIL PRESSURE |
|
Definition
| ENGAGED 230-290 PSI DISENGAGED 58-66 PSI |
|
|
Term
| NORMAL REDUCTION GEAR OIL TEMPERATURE |
|
Definition
|
|
Term
| HOW MANY PARTS ARE TO THE DDEC SYSTEM |
|
Definition
| 7 THEY ARE THE EDM,CSIM,ERIM,EGIM,MIM,ECM, AND THE EUI |
|
|
Term
| WHAT IS THE MODEL OF THE DETROIT DIESEL |
|
Definition
|
|
Term
| WHAT IS THE BASE HORSE POWER |
|
Definition
|
|
Term
| HOW MANY GALLONS PER MINUTE DOES THE JABSCO RAW WATER PUMP DISPLACE |
|
Definition
|
|
Term
| HOW MANY MAJOR COMPONENTS ARE THERE IN THE RAW WATER SYSTEM AND WHAT ARE THEY |
|
Definition
| 11 THEY ARE AS FOLLOWS, SEA VALVE, SEA STRAINER, R/W PUMP, F/O COOLER, HEAT EXCHANGER, RESTRICTOR PLATE, STEERING SYSTEM COOLER, SHAFT SEAL, R/G OIL COOLER, DEICING VALVE, MUFFLER |
|
|
Term
| AT WHAT DEGREE DOES THE RAW WATER BEGIN TO COOL THE REDUCTION GEARS |
|
Definition
|
|
Term
| WHAT COOLS THE ECM AND AT WHAT DEGREE |
|
Definition
| F/O COOLS THE ECM AND IS MAINTAINED AT 90 DEGREES |
|
|
Term
| THE JACKET WATER SYSTEM HAS A CAPACITY OF HOW MANY GALLONS AND IS MADE UP OF WHAT |
|
Definition
| 12 GALLONS OF 50/50 POWER COOL AND DISTILLED WATER |
|
|
Term
| HOW MANY GPM DOES THE JACKET WATER PUMP |
|
Definition
|
|
Term
| WHAT KIND OF LUBE OIL AND WHAT CAPACITY IS USED IN THE MDE |
|
Definition
|
|
Term
| HOW MANY GPM IS THE OIL PUMP RATED AT |
|
Definition
|
|
Term
| AT WHAT TEMPERATURE DOES THE THE LUBE OIL COOLER MAINTAIN OIL |
|
Definition
| BETWEEN 200-250 DEGREES F |
|
|
Term
| WHAT ARE THE CHARCTERISTICS OF THE LUBE OIL FILTER |
|
Definition
| SIMPLEX SPIN ON TYPE FILTER RATED AT 10 MICRONS |
|
|
Term
| HOW MANY COMPONENTS ARE THERE TO THE F/O SYSTEM AND WHAT ARE THEY |
|
Definition
| 11 THEY ARE AS FOLLOWS; FUEL TANK, FUEL TANK VENT, EMERGENCY CUTOFF VALVE, PRIMARY FILTER, PRIMING PUMP, FUEL PUMP, SECONDARY FILTER, RESTRICTED ORIFICE, FUEL COOLER, ECM FUEL COOLER PLATE AND THE PRESSURE RELIEF CHECK VALVE |
|
|
Term
| WHAT ARE THE PARAMETERS OF THE FUEL TANK |
|
Definition
|
|
Term
| HOW MUCH FUEL IS UNUSABLE |
|
Definition
|
|
Term
| HOW MANY INCHES OFF THE BOTTOM OF THE TANK DOES THE FUEL SUCK OFF |
|
Definition
|
|
Term
| WHAT PERCENT OF FUEL IS RETURNED TO THE TANK |
|
Definition
|
|
Term
| WHAT BRAND OF FUEL FILTER IS USED |
|
Definition
|
|
Term
| HOW LONG WILL THE MDE RUN FOR AFTER PULLING THE EMERGENCY FUEL SHUT OFF VALVES AT FULL THROTTLE AND AT IDLE |
|
Definition
| 30 SECONDS AT FULL THROTTLE AND 5 MINUTES AT IDLE |
|
|
Term
| FOR EVERY 10 DEGREES OF TEMPERATURE ABOVE 90 DEGREES THERE IS A LOSS OF WHAT PERCENT IN HORSEPOWER |
|
Definition
|
|
Term
| WHAT IS THE SIZE OF THE RESTRICED ORIFICE AND WHAT DOES IS DO |
|
Definition
| .080 AND PROVIDES BACK PRESSURE TO MAINTAIN SYSTEM PRESSURE AND COOLING |
|
|
Term
| WHAT DOES THE VACUUM LIMITER DO |
|
Definition
| PREVENTS THE AIR INTAKE FROM CREATING A VACUUM IN THE ENGINE BY ALLOWING AIR FROM THE ENGINE ROOM INTO THE SYSTEM |
|
|
Term
| DEFINE ECM AND HOW MANY ARE THERE |
|
Definition
| ENGINE CONTROL MODULE THERE IS ONE LOCATED ON EACH MDE A TOTAL OF 2 |
|
|
Term
| WHAT SEVEN THINGS DOES THE DDEC SYSTEM DO |
|
Definition
| ENGINE GOVERNING, COLD START FUELING AND TIMING, ENGINE PROTECTION AND DIAGONISTICS, INJECTION TIMING, RATED SPEED AND POWER, SENSOR CALIBRATION, SMOKE CONTROL |
|
|
Term
| DEFINE MIM AND HOW MANY ARE THERE |
|
Definition
| MANUFACTURERS MARINE INTERFACE MODULE, THERE IS 1 LOCATED ON EACH MDE A TOTAL OF 2 |
|
|
Term
| DEFINE ERIM AND HOW MANY ARE THERE |
|
Definition
| ENGINE ROOM INTERFACE MODULE THERE IS ONE LOCATED ON THE STARBOARD BULKHEAD IN THE AUX SPACE |
|
|
Term
| DEFINE EGIM AND HOW MANY ARE THERE |
|
Definition
| ELECTRONIC GEAR INTERFACE MODULE THERE ARE 2 AND THEY ARE BOTH LOCATED IN THE AUX SPACE BELOW THE ERIM |
|
|
Term
| DEFINE CSIM AND HOW MANY ARE THERE |
|
Definition
| CONTROL STATION INTERFACE MODULE THERE ARE 3 CSIMS AND THEY ARE ALL LOCATED IN THE ENCLOSED STEERING |
|
|
Term
| DEFINE EDM AND HOW MANY ARE THERE |
|
Definition
| ELECTRONIC DISPLAY MODULE THERE ARE 4 EDMS 2 LOCATED ON THE OPEN STEERING AND 2 LOCATED IN THE ENCLOSED STEERING |
|
|
Term
| WHAT IS THE NAME OF THE REDUCTION GEAR AND WHAT IS THE GEAR RATIO IN FORWARD AND REVERSE |
|
Definition
| REINTJES REDUCTION GEAR WVS 234 UP 2:1 FORWARD AND REVERSE |
|
|
Term
| WHAT KIND OF OIL AND WHAT CAPACITY IS MAINTAINED THE THE REDUCTION GEARS |
|
Definition
| 7.1 GALLONS OF 30 WT NON DETERGENT |
|
|
Term
| AT WHAT DEGREE WILL THE HIGH OIL TEMP ALRM SOUND FOR THE REDUCTION GEARS |
|
Definition
|
|
